HHO Kits-HHOKitsDirect.com

Posts Tagged ‘hydrogen generators’

Well it has been a very busy last couple of months as we worked like crazy to locate a new building, negotiate the terms, remodel the whole front end, then move into the place. All while trying to maintain some sanity and keep the manufacturing going.

We have finally been able to catch our breath and are just about settled in…few little small things but overall we are in full swing as we prepare for the next big launch of new products.

Here are a couple of photos of our shop and office:

Photo of the front of our new operations

Front lobby and offices

Sneak peek into Shanna's office from the conference room

My office and Accounting - Jenee' hard at work...

More pictures to follow later.

If you live in the area- come on by and see us or pick up an HHO generator for your own car!

Thanks!

Bob Volk

Similar to the Itasca motorhome that got a 30% increase using our hho generator

I got this email today sent to me from one of our customers this weekend.  This was a tough one because it was a huge 35′ long  Itasca motorhome with a hefty 6.4 L Ford V-10. I wasn’t sure what kind of  result he would get, but with that size vehicle- any increase is good.

It was a long email, so I will let him tell it it some of these excerpts below:

“Just thought I would let you know I have the 773 installed in my 2000 Itasca 35′ motorhome. with 75700 miles on it - Last year we put on about 18000 miles. Engine 6.8L V10 Ford on and F550 Chassis

took it for a break in run - the gas tank is hard to fill so I may be out a little as far as how much gas it took - but anyway I topped the tank and went for a 60 mile ride (actually it was 59.3 miles) at 57 MPH using cruise most of the time we had 24 miles of about 20 MPH crosswinds and about 15 miles of the same tailwind - the rest was headwind.

It used 5.3 gal US (actually 20.1 liitres) 87 octane (topped it up again)

This works out to 11.29 MPG

The best we have ever done was 8.8 MPG with Lucas additive and 91 octane
Mind you my motorhome is empty at this point so we will have to see what it is like once it is loaded. But we have never done that high empty or otherwise.

The engine runs as smooth as ever I did notice that the exhaust pipe sticking out the side was very hot. (seemed hotter than usual?)

It also smelled different - as in didn’t smell hardly at all.”

Notice he said that the 8.8 was done with 91 octane and a fuel additive and the test he ran was using 87 octane gas and no additive. Either way- that adds up to almost 30% on a huge motorhome using just one of our 773 HHO generator kits!

Great to hear- keep up the great work Henry!

Bob

There was a recent article published in Gizmag about the need to improve the fuel economy of  heavy vehicles specifically the big rig tractor trailers like Freightliner Trucks, Kenworth Trucks, International Trucks, Mack Trucks, Navistar Trucks, Peterbuilt Trucks, and more.

Tractor trailers and Big Rigs Need to Reduce Diesel emissions and increase mileage

The article speaks to the need of increasing the mileage and reducing the emissions of these big rigs that are the backbone of our economy both here in the USA and around the world. The problem is that the solutions they suggest cost $15,000 - $85,000 to implement and the agencies involved want to put that heavy burden on the poor truckers that are already spending $5000 a month in fuel costs! I know because they call me up and talk to me almost every week - desperate for any solution to the heavy burden of rising diesel costs and onerous emissions requirements.

Well we are working day and night to offer the solution that will bring relief- both to the fuel expense AND the newly regulated emissions requirements. We are hard at work developing a new HHO Generator aimed specifically at the Big Rig industry based on our breakthrough Hybrid Cell technology! We will be releasing it this year, and if the initial tests are any indication, it’s going to change the face of the industry!

So hang in there all you truckers- hard working men and women that sacrifice being at home with their families, so they can get merchandise delivered from manufacturers to consumers and keep our economy rolling. We are close to revealing a product that will blow you away, meet every emissions standard for decades, AND give you an increase in your mileage, putting money back into your pocket instead of big oil companies!

Here are excerpts from that article:

“While there are fuel consumption standards for passenger cars, there is no such regulation of medium- and heavy-duty vehicles in the U.S. With such vehicles accounting for about 26 percent of the transportation fuel used in the U.S. regulators are looking to establish fuel economy standards for these vehicles in the next few years. Now a new U.S. report has been released recommending the best ways to measure and regulate fuel economy for these vehicles, and assess technologies that could improve it. Amongst its findings, the report says that some vehicles could cut their fuel use by about 50 percent through the use of a combination of technologies.

The congressionally mandated report was put together by the National Research Council (NRC) at the request of the National Highway Traffic Safety Administration (NHTSA). It was in response to legislation passed in Congress in 2007 requiring the U.S. Department of Transportation to establish fuel economy standards for medium- and heavy-duty vehicles for the first time in history.

The committee estimated the improvements that various technologies could achieve over the next decade in seven vehicle types. The report found that:

• using advanced diesel engines in tractor-trailers could lower their fuel consumption by up to 20 percent by 2020, and improved aerodynamics could yield an 11 percent reduction;
• hybrid powertrains could lower the fuel consumption of vehicles that stop frequently, such as garbage trucks and transit buses, by as much 35 percent in the same time frame;
  • while the cost of making these improvements would be passed on to vehicle purchasers, the report notes that many of these suites of technologies would pay for themselves even at today’s energy prices, under the committee’s assumptions;
• using a combination of technologies tractor-trailers could cut their fuel use by about 50 percent by 2020 for about US$84,600 per truck, which would be cost-effective over ten years with gas prices of at least US$1.10 per gallon;
• fuel use of motor coaches could be lowered by 32 percent for an estimated US$36,350 per bus, which would be cost-effective if the price of fuel is US$1.70 per gallon or higher;
  • for other vehicle classes, the financial investments in making improvements would be cost-effective at higher prices of fuel;
• the NHTSA should regulate the final-stage vehicle manufacturers rather than component makers, as the former has the greatest control over the vehicle’s design;
• the adoption of nontechnical methods to lower fuel consumption, such as providing incentives to train vehicle operators in efficient driving techniques, could result in fuel savings of anywhere from 2 percent to 17 percent.”

And then of course- there is the bureaucrats solution which is typical of an idiot who has never had to run a business or work a real job in his life; RAISE TAXES and penalize the poor truckers already spending half their income on fuel:

“However, one way to avoid the complexity of regulating different types of vehicles suggested by the report would be to impose a fuel tax, which would induce firms to optimize the fuel-efficiency of their operations. The report urges Congress to consider this approach. Another alternative approach - applying a cap-and-trade system to trucking companies similar to the one that Congress is considering as a way to lower CO2 emissions - would similarly provide these companies with an incentive to adopt fuel-saving technologies and operational methods.

The report is intended to influence the choices that will be made over the course of the next few years in establishing the regulatory design for medium- and heavy-duty vehicle fuel consumption standards for the next several decades.

Copies of the full report, “Technologies and Approaches to Reducing the fuel Consumption of Medium and Heavy-Duty Vehicles,” are available from the National Academies Press.

You can read the whole article here: GIZMAG

Hang in their truckers- we are coming to the rescue with our new line of HHO generators designed specifically for you!

Bob Volk, CEO
Transitional Technologies, LLC

I got this email today from a customer in Brisbane Australia who is just starting to test the whole HHO Generator experience. He decided to try it in his old Diesel Powered Farm Tractor with remarkable results in cleaning up the smog-choking black smoke….

Here are a few excerpts…

“I’m currently a member, having bought the ebook, built and installed my first brute force system into an old, sick and unloved ‘83 3litre Nissan Patrol Diesel.

It used to produce enough black smoke to rival Icelandic volcanoes, but now after 2.5 tanks of diesel it has improved remarkably, running cleaner and slightly cooler. For an old farm truck its a massive improvement.

Next on the list is my English toy, a ‘67 Rover P5 3litre petrol and then the farm tractor. Older technology I can deal with, but my real question relates to our new cars. ‘07 Nissan X-Trail 2.5 petrol and ‘05 Hyundai 2.9 CRDi diesel 4WD. Both have ECU units managing the fuel systems. I need to buy two HHO-772 units for them, as the home-built units JUST WONT FIT!

Also I’m quite keen to be able to try to create a secondry income from this through affilation and/or sales, after I have my own units installed and can prove/show that it works. Are dealers able to buy units at a better price than normal”

Look forward to hearing from you soon.
Regards, John Z., Brisbane, Australia.

Thanks John! I love how HHO gas cleans up the dirty spewing emissions from cars and trucks! If this is all it did- it would be worth putting an HHO generator on every vehicle…thankfully, they also increase fuel mileage!

Yes- our products also work with new cars using either the efie or mileage chip…
And yes- you can sign up to be a dealer or affiliate here to get volume pricing: http://www.hhokitsdirect.com/affiliates.php

To see the complete line of generators: http://www.hhokitsdirect.com/HHO-Generators.php

Thanks!

Bob

It’s difficult for many of us (including me) to convert our US standard formula of Miles Per Gallon for our cars into Kilometers Per Liter (the more commonly used measurement around the world).

If you were to tell me  your mileage result with our Hybrid Cell HHO Generator was 67 MPG (like our recent customer testimonial in Florida!) I would drop my mouth to the floor in amazement (which I did!).

But if you were to tell me you got 28.8 Kilometers per liter, or 80.47 Miles per gallon (UK gallons) my eyes would glaze over because i wasn’t raised around those measurements.

I’m thinking our friends overseas might have the same issue when I mention everything in miles per gallon US.

So I found this easy to use Mileage Converter to convert what I tell you to Kilometers per Liter or UK Miles per gallon. Click HERE to see it.

Bob Volk

Yes! You read that correct. I’m not talking about 67% increase here, I am talking 67 MPG using our 772 HHO generator and a mileage chip!

What was it in you ask? A Honda? A Toyota? Hyundai, Subaru, or Mitsubishi?

NOT even close! How about a 1997 Oldsmobile Delta 88? Unbelievable? That’s what I thought too. Here are the very specific details from our friends Paul and Sandy over at Energy Evolutions in Florida.

The project car with HHo generator and mileage chip

First, let me say this was NOT smooth sailing from the beginning. In fact the first mileage reports were disappointing, almost non-existent…so we went through a series of checklists: Power connections good? Fuse OK? HHO Generator making gas? Reservoir and electrolyte properly filled and mixed?
Everything should have been fine, but for some reason the mileage was not there….

We finally narrowed it down to a faulty mileage chip. Even though it was new, for some reason it wasn’t calibrating properly. So I had Paul mail it back to us, and we flashed a brand new chip for him- double checking all the parameters and running diagnostic checks on it just to make sure. I also included a Digital Quad Efie just in case the mileage chip did not function properly this time. It was the second set as the first one disappeared in UPS transit somehow…

Well- that appeared to fix the problem! I will let Paul’s email to me today tell the rest of the story…

Bob:

Well, Sandy and I had an exciting day.  We got our chip installed and calibrated.  Then we did our standard 140 mile (Exactly) test trip as we always do.  Here’s a break down of the “Standard Test Trip”:

- Fill car up at the Mobil station at the corner of Flamingo and Griffin Road (Two clicks on the top off).

- Drive down Griffin to I-75 N

- Drive 65 MPH on Cruise Control down I-75 N to the Florida Route 27 N

- Drive 65 MPH on Cruise Control down FL 27 N (except where otherwise posted)

- Pull into McDonalds in Clewiston and park in same rear parking space

- Turn engine off, and go in and order cheap lunch

- Return to Cooper City, FL via same route, backwards, using same speed and driving techniques.

- Stop at same Mobil Station, and same pump to fill up using same technique

- This total trip is Exactly 140 Miles.

So, here’s the breakdown:

- Nothing hooked up, stock from factory - 30 MPG  ( I was impressed with this and never thought we could do better)

- With the HHO System installed in “Best Manner” - 38 MPG (Not bad - But, needed to do better)

- With Milage Chip installed & Calibrated - (SIT DOWN NOW) - 67 MPG

Can you imagine a thirteen year old 4,000 pound piece of American Luxury steel (1997 Olds 88) going down the road at 67 MPG.  Well, Sandy and I are still not believing our eyes.  So, later this week we’ll make another “Standard Test Run”, just to be sure.

Enjoy,

Paul Hendee

Energy Evolutions

Effective Energy Solutions For Industry Today

URL:  http://www.energy-evolutions.com

Blog:  http://www.energy-evolutions.com/blog

For those who want to see more pictures of the install, go to our Facebook page here: (just click on this link) HHOKITSDIRECT.COM FACEBOOK

Thanks Paul and Sandy for a great install and sticking with it even when the results weren’t easy! Obviously your hard work has paid off…

Bob Volk,CEO
Transitional Technologies, LLC

Wow! Something must have been in the air yesterday… two encouraging emails from our customers in one day = great day!

HHO Generator installed in front of 2002 Nissan Xterra

This is an excerpt from Gabriel in Africa. It is his first install and was a bit challenging the first time, taking him a bit longer than expected (the first is always the hardest - they get easier as you understand the process). You can see his post back in January here: Great HHO Generator Mileage Increase Testimony

Gabriel has been corresponding back and forth, having trouble with the efie and mileage losses, not gains (sometimes this happens- the car computers are different everywhere and we have to take time to figure it out…) It is always frustrating when we get a stubborn car, but this is more proof that if you stick with it- you can get the victory…

(I think he is referring to 120 mph in kph…but from the looks of it he has almost doubled his mileage going from 70 to 132 miles…)

Here is an excerpt from that email…

Hello Bob,

Top of the morning to you. Since our last correspondences, i have made a lot of changes to my HHO system. I am still testing and so cannot give you a final result now. However, over this last weekend, I had filled my tank on Saturday and traveled a distance of 132miles on high speed. My average speed was 120mph. On arriving back home, my fuel gauge was at “half-tank” and my mileage was 132. I was so pleased. during the whole journey, there wasn’t any form of degradation in speed (performance) and fuel economy. Prior to the installation of the HHO system, I at best, made 70miles (and so bad a performance) on a half-tank.

What changes did I make?

* I changed the electrolyte of the HHO generator and made it new.

* I increased the current passing through the system from 12A to 22A (by adding more NAOH)

*I changed my air-filter (the former was torn and I didn’t even know it)

I however think that the major change that i made was the production of more HHO into the system. At 22amps, I was generating so much gas (I dont have an accurate reading yet) that condensation forms very rapidly at the tail pipe when I do a cold start in the morning.

Thanks Gabriel! I have recommended this to several people who have tested and are having problems- clean out the the system. Sometimes it helps to soak the generator with CLR (Calcium Lime Rust) cleaner. then flush and refill with clean water and fresh electrolyte.

So for those of you having a few challenges with your installation, be encouraged. It’s worth it when you start seeing gas savings like this….

Bob Volk, CEO
Transitional Technologies, LLC

2009 Yukon with HHO Generator

I just got this great email in yesterday from one of our customers that had bought our 772, and came back to get the mileage chip for his 2009 GMC Yukon.

That’s a BIG vehicle - wasn’t sure how the 772 would fare…

Hugh used to live here in the Bay Area and comes back regularly from Texas where he resides now. He was in town a couple weeks ago and called me- wanted to stop by and pick up a mileage chip before heading back home. We talked for an hour at the shop - really nice guy.

This is an excerpt from the email he sent me…

Hi Robert, It was a pleasure meeting with you a couple of weeks ago. I have now arrived in Texas and was pleased with my gas improvement. I had a 67% improvement with my 772 Generator in my Yukon….

…I would like to talk with you further about the possible Distributorship in the Dallas/Fort Worth area. I also have received some inquiries about prices for the units.
Whenever you have the time, give me a call or send me a email back and we can discuss it further. I can come back to the Bay Area at anytime also.
Thanks, Hugh Carter

67% increase on a Yukon- that is what I like to see!

Keep sending me the good reports people! I want our customers to see what is possible with a good installation, a great HHO Generator, and some time…

Bob Volk,CEO
Transitional Technologies, LLC

I just had Roger send me an email last night with his newest independent HHO gas verification. Seems he wanted to make sure that all the tremendous mileage gains he has been getting (using our 772 HHo Generator and the new HHO high mileage chip) has not affected his emissions in a negative way.

So he took it down to the AirCare Vehicle inspection station to run a voluntary test.

He graciously scanned it and sent it on to me. The results are no less than spectacular!

The test was called the IM240 which is a test done on a dyno simulating stop and start driving, up/down hills, hard accelerating and idling. Test lasted about 5 minutes and recorded 6kms on the speedo

The emissions report verifies once again how viable HHO technology is and how a good HHO Kit can really impact our environment in a positive way.

Take a minute and check it out…click on the emissions report to see a larger image and check out the 3 numbers that will blow you away!

It just keeps getting better! OK everybody- lets keep the momentum going! If you have more verifications, especially emissions reports like these, send me copies so I can post them to my blog. The more reports we get, the more it verifies and validates that what we are doing is not only amazing for mileage, but incredible for the environment.

Bob

Another really fantastic post comes from our recent customer George White from Australia!

George wrote to tell me of his amazing experience using our 773 generator installed on his huge tractor. Now, I’m not that familiar with these babies, so i googled one to post so you could see the size beast he bought our 773 for.

similar to the one using our 773 HHO Generator to get an incredible run time increase!

He calls it an 85DCAT which he used on his 600 acres for over 30 hours of test time…so this was not a quick run to the gas station and back- this was hard working machinery used to make a living on some kind of farm land.

Now, I really didn’t design it for this big of a machine, but I did build it to withstand the daily rigors of hard work, and because our plates are completely enclosed in the new Hybrid Cell, there is no chance of them shorting out  in rugged situations like this where anything could be jammed up against  it (unlike the dry cells with exposed plate edges that could easily be shorted). I will let him tell you in his own words…

Bob Last year I built my own HHO Generator from your plans and it took my 18 year old Nissan patrol from 17 mpg to 23 mpg so when I seen your new Mega Brick Icouldnt wait to install one on my tractor so I ordered your 774 Mega Brick and installed it in my Cat 85D tractor ( 370 HP )and on first test ( 30 hours over 600 acres )I have taken my fuel from Last year average of 44 Liters per hour to 26.6 liters per hour (I am in Australia so there is 3.8 Liters in a US gallon ) So I have half paid for it already, Amazing.

Can”t wait to get back in the tractor.

Please keep up your wonderful work.

Regards

George

Thanks George! We will… By the way, just a small correction, we do not have a 774, he was talking about our Monster Mega-Brick 773 HHO Generator. .

Now if you do the math- that little 773 has given him a 65% increase per hour on a 370 HP vehicle - that is incredible! You are talking hard dollars in the pocket of a hard working Australian here- and THAT is what it is all about people!…

Keep up the good work George!

The rest of you- let’s get those babies put in and start getting some results…

I love my job!

Bob